回转式鼓风机安装尺寸
Installation dimension of rotary blower
1、 体积小、风量大、噪声低、耗能省(回转式鼓风机采用运转压缩空气的原理，虽然体积小，但风量大、，静音运转是其他形式的风机无法比拟的;
1. Small volume, large air volume, low noise and low energy consumption (the rotary blower adopts the principle of operating compressed air. Although the volume is small, it has large air volume, energy saving and silent operation, which is unmatched by other types of fans;
2、运转平稳，安装方便(小型机种运转时只要放置妥当则振动很小，不需要加装防振装置，安装方便);
2. Stable operation and convenient installation (small models have little vibration as long as they are properly placed during operation, so it is not necessary to install anti vibration devices, which is convenient for installation);
3、抗负荷变化，风量稳定(例如：污水处理曝气槽压力变化，则负荷变化，但风量随压力变化而变化甚微)。
3. Resistant to load change and stable air volume (for example, if the pressure of sewage treatment aeration tank changes, the load changes, but the air volume changes little with the pressure change).
4、附有空气室，散气平稳(全部机种附有空气室，可防止空气脉动，散气平稳);
4. Air chamber is provided for stable air dispersion (air chamber is provided for all models to prevent air pulsation and smooth air dispersion);
5、材质精良，结构巧妙，性能好(鼓风机全部采用的材料，结构精巧，坚固耐用，性能好，长期使用故障少);
5. Excellent material, ingenious structure and good performance (all blowers are made of high-quality materials, with exquisite structure, durability, good performance and few long-term faults);
6、保养简单，故障少，寿命长(低转速，磨损小，寿命长)。
6. Simple maintenance, few faults and long service life (low speed, little wear and long service life).
回转式鼓风机安装效果
Installation effect of rotary blower
1、搬运回转式鼓风机时请特别注意，要避免回转式鼓风机受到碰伤和冲击，且不能把回转式鼓风机立起来搬运，以防止润滑油从油箱内倒出来。
1. Please pay special attention to safety when handling the rotary blower. Avoid bumping and impact on the rotary blower, and do not lift the rotary blower to prevent the lubricating oil from pouring out of the oil tank.
2、风机房应留有通风口并安装 换气扇 ，通风口要设在上下两处便于空气对流，以防止机房内温度过高影响回转式鼓风机正常运行。
2. The fan room shall be provided with air vents and installed with ventilation fans. The vents shall be set at the upper and lower places to facilitate air convection, so as to prevent excessive temperature in the machine room from affecting the normal operation of the rotary blower.
3、机房内壁周围装有消音材料以降低噪音。
3. It is better to install silencing materials around the inner wall of the machine room to reduce noise.
4、回转式鼓风机应水平安装。
4. The rotary blower shall be installed horizontally.
5、配气管径不应小于回转式鼓风机排风口径，并注意管内清洁，送气管应安装在水面以上，以防止管内进水造成起动时压力过大。
5. The air distribution pipe diameter shall not be less than the exhaust diameter of the rotary blower, and attention shall be paid to the cleanness in the pipe. The air supply pipe shall be installed above the water surface to prevent excessive pressure during startup caused by water inflow in the pipe.
6、接管时注意不要把止回阀拧倒(止回阀凸起部分应朝上)。
6. Be careful not to screw down the check valve (the convex part of the check valve should face upward) when connecting the pipe.
7、请正确接配电线并注意电机转向与回转式鼓风机旋转方向标记一致。
7. Please connect the distribution wire correctly and note that the rotation direction of the motor is consistent with that of the rotary blower.
8、采用两台回转式鼓风机交替运行时，应避免在短时间内频繁交换起动风机，希望一台回转式鼓风机的连续运行时间不低于12小时。
8. When two rotary blowers are used for alternate operation, frequent exchange of starting fans in a short time shall be avoided. It is hoped that the continuous operation time of one rotary blower shall not be less than 12 hours.
以上就是舒适为大家介绍的回转式鼓风机的一些简单知识，在鼓风机的市场中，不同种类的鼓风机是有很多的，而回转式鼓风机能在众多的鼓风机中脱颖而出是因为它优良的质量以及良好的通风效果。回转式鼓风机的安装也是使用中一个非常重要的环节，只有安装好了才能发挥出它好的效果。
The above is some simple knowledge of the rotary blower introduced to you by comfort. In the blower Market, there are many different types of blowers, and the rotary blower stands out among many blowers because of its excellent quality and good ventilation effect. The installation of the rotary blower is also a very important link in the use. Only when it is installed can it play a good role.
TEL:400-9901-557
TEL:18678880998
公司地址：山东省济南市章丘区相公街道大康村村南
济南道源丰达机械制造有限公司
备案号：鲁ICP备2022009540号-1 鲁公网安备37018102000745号
